Sponsor message
Now new in the US - Dietary diformates Made in Germany Learn more

Evaluation of Deoiled Distiller's Dried Grains with Solubles for Broilers

7 January 2015, at 12:00am

Broilers can perform adequately with a diet including low-oil distiller's dried grains with solubles (DDGS), according to a new study at Auburn University, but researchers warn that the diet may be more expensive due to the lower energy contribution of the DDGS.

The ethanol industry produces a variety of co-products, ranging from dehydrated corn germ meal to corn bran, with high-oil distiller's dried grains with solubles (DDGS) being approximately 31 per cent crude protein (CP), 12 per cent ether extract (EE), and 44 per cent neutral detergent fibre (NDF), according to W.A. Dozier, III and J.B. Hess of Auburn University.

They explain that, with the ethanol industry seeking alternate profit streams from ethanol plants and the biodiesel industry seeking alternatives to high-priced soybean oil, one potential additional product is corn oil extracted from existing ethanol plants. In extracting the oil in DDGS, crude fat levels can drop from approximately 12 per cent to six per cent EE, while in contrast, concentrations of other nutrients in the resultant reduced-oil DDGS are increased.

The objectives of this study, sponsored by US Poultry & Egg Association were to

  1. determine metabolisable energy (AMEn) and amino acid (AA) digestibility of three sources of DDGS and
  2. examine growth and meat yield responses of broilers fed diets consisting of three sources of DDGS fed to different inclusion levels from one to 35 day and one to 49 day of age. Diets were formulated using AMEn and digestible AA values determined from Objective 1.

In Experiment 1, AMEn was determined as 1,975, 2,644 and 3,137kcal per kg for low-oil DDGS (L-DDGS), medium-oil DDGS (M-DDGS) and high-oil DDGS (H-DDGS), respectively.

In Experiment 2, apparent amino acid digestibility was determined feeding either L-DDGS, M-DDGS or H-DDGS.

Apparent amino acid digestibility coefficients were negatively affected by oil extraction for methionine, lysine, threonine, tryptophan and arginine. Conversely, no differences in apparent amino acid digestibility coefficients were seen for isoleucine, leucine and valine.

These results indicated that L-DDGS had lower apparent amino acid coefficients for methionine, lysine, threonine, tryptophan and arginine than H-DDGS and that this should be considered when formulating diets using deoiled DDGS.

In Experiment 3, diets were formulated to contain L-DDGS, M-DDGS and H-DDGS at moderate (5, 7 and 9 per cent) and high (8, 10 and 12 per cent) inclusion rates of DDGS and fed to male broilers from one to 35 days of age.

Broilers receiving diets with a higher inclusion of DDGS had lower bodyweight gains and poorer feed conversion ratios. Oil content of the DDGS source did not affect live performance. Abdominal fat yield was reduced and breast yield was increased for broilers receiving the H-DDGS source at moderate inclusion levels.

In Experiment 4, diets were formulated to contain L-DDGS, M-DDGS and H-DDGS at moderate (5, 7, 9 and 11 per cent) and high (8, 10, 12 and 14 per cent) inclusion rates of DDGS and fed to male broilers from one to 49 days of age.

Neither DDGS source or inclusion rate affected cumulative performance nor parts yield.

In general, Dozier and Hess concluded, the data indicate acceptable performance can be obtained with deoiled DDGS if diets are formulated to the actual nutrient values of DDGS.

Using an L-DDGS source can provide adequate performance but may increase diet cost because of its lower energy contribution, the Auburn authors added.

January 2015

Sponsored content
Our Formi products fulfil tomorrow’s requirements today.

Formi NDF and the 3rd Generation acidifier Formi 3G have been formulated to replace the need for in-feed antibiotics, by ensuring a strong antibacterial impact against Gram negative and Gram positive bacteria.

The Formi product line, based on Addcon’s patented diformate technology ensures optimal efficiency, highest growth rates and maximum safety, which are key requirements in animal production worldwide – and are now available in the USA.

Learn more